Stirred tank reactor with dual impeller Rushton turbine for application of wastewater treatment - Process optimization and CFD simulation
سال انتشار: 1402
نوع سند: مقاله ژورنالی
زبان: انگلیسی
مشاهده: 76
فایل این مقاله در 20 صفحه با فرمت PDF قابل دریافت می باشد
- صدور گواهی نمایه سازی
- من نویسنده این مقاله هستم
استخراج به نرم افزارهای پژوهشی:
شناسه ملی سند علمی:
JR_AET-9-3_002
تاریخ نمایه سازی: 3 آبان 1402
چکیده مقاله:
The treatment of industrial wastewater by economical and efficient methods is being explored to improve treatment efficiency and costs. Wastewater treatment via biological methods to reduce carbonaceous matter is common in the form of an activated sludge process (ASP). In the current work, the aerobic decomposition of waste was carried out in a reactor with constant stirring with a Rushton type turbine. The optimum values of the flow rate of air were obtained for two reactor impeller configurations for better waste degradation. The extent of degradation in the stirred tank reactor was studied for different values of impeller clearances. Two configurations, C۱ and C۲, were investigated. It was observed that under a continuous air supply for ۳۶ hours, the impeller configuration C۲ provided ۸۰% degradation compared to ۷۴.۴ % for C۱. Increased values of superficial gas velocity (UG) and impeller speed resulted in decreased degradation due to shear stress on microorganisms for two impeller configurations. The hydrodynamic study confirmed that the impeller configuration C۱ required less power consumption than C۲ for the same operating condition. The k-epsilon turbulent model and the population balance model were used in combination. The models were validated with the experimental results of the hydrodynamic parameters for the values of operating parameters over a considerable range. The forecasting of mass transfer coefficients from different models was compared with practically determined values for the two configurations of impeller positions in the tank.
کلیدواژه ها:
Biological treatment ، Optimization ، small scale industrial wastewater ، coefficient ، Configurations hydrodynamics ، Fluid dynamics
نویسندگان
Shivanand Teli
Chemical Engineering Department, GF’s Gharda Institute of Technology, Khed, India
Sunil Kulkarni
Chemical Engineering Department, GF’s Gharda Institute of Technology, Khed, India
مراجع و منابع این مقاله:
لیست زیر مراجع و منابع استفاده شده در این مقاله را نمایش می دهد. این مراجع به صورت کاملا ماشینی و بر اساس هوش مصنوعی استخراج شده اند و لذا ممکن است دارای اشکالاتی باشند که به مرور زمان دقت استخراج این محتوا افزایش می یابد. مراجعی که مقالات مربوط به آنها در سیویلیکا نمایه شده و پیدا شده اند، به خود مقاله لینک شده اند :